Product ID:CPS 241403, INSULATING OIL
MSDS Date:09/25/1986
FSC:9150
NIIN:00N030273
MSDS Number: BNNSX

CHEVRON

RICHMOND, CA 94804-0054
US

Emergency Phone: 415-233-3737

Info Phone: 415-233-3737

Cage: 0AHD1

CHEVRON ENVIRONMENTAL HEALTH CENTER INC

4054 RICHMOND, CA 94804 US

Telephone: 800-582-3835

Cage: 0AHD1

HIGHLY REFINED BASE OIL CONTAINING INGREDIENTS 2-4.

RTECS: 9999999ZZ

Fraction By Weight: 100%

OSHA PEL 5MG/M3 (OIL MIST)

ACGIH TLV: 5MG/M3;10 STEL(MIST)

MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-REFINED

CAS: 64741-96-4

RTECS: PY8040001

OSHA PEL 5MG/M3 (OIL MIST)

ACGIH TLV: 5MG/M3;10 STEL(MIST)

MINERAL OILS, PETROLEUM DISTILLATES, HYDROTREATED (SEVERE)

CAS: 64742-52-5

RTECS: PY8035001

OSHA PEL 5MG/M3 (OIL MIST)

ACGIH TLV: 5MG/M3;10 STEL(MIST)

PETROLEUM DISTILLATES, CLAY-TREATED LIGHT NAPHTHENIC

CAS: 64742-45-6

RTECS: SE7449750

OSHA PEL 5MG/M3 (OIL MIST)

ACGIH TLV: 5MG/M3;10 STEL(MIST)

LD50 LC50 Mixture:LD50:(ORAL,RAT)>22 G/KG.
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES:EXPECTED TO CAUSE NO MORE THAN
MINOR IRRIT. SKIN:EXPECTED TO CAUSE NO MORE THAN MINOR IRRIT
FOLLOWING PRLNGD/ FREQUENTLY RPTD CONT. APPLICATION ONTO SKIN ON
RABBITS PRODUCES SLIGHT ERYTHEMA & EDE MA. INHAL:NOT EXPECTED TO BE
ACUTELY TOX BY INHAL. BRTHG MINERAL OIL MIST @ CONC IN AIR THAT
EXCEEDS FED(EFTS OF OVEREXP
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OSHA EXPOS STD CAN CAUSE RESP
IRRIT/DISCOMFORT. INGEST:NOT EXPECTED TO HAVE ACUTE SYSTEMIC TOX.
NOTE TO MD:INGEST OF PROD/SUBSEQUENT VOMIT CAN RESULT IN ASPIR OF
LIGHT HYDROCARBON LIQ WHICH C AN CAUSE PNEUM. SIGNS & SYMPT OF RESP
TRACT IRRIT MAY INCLUDE, BUT MAY NOT BE LIM TO, DEPENDING ON CONC &
LGTH (SUPDAT)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYES:FLUSH IMMED W/FRESH H2O FOR @ LST 15 MIN WHILE HOLDING
EYELIDS OPEN. IF IRRIT PERSISTS, SEE MD. SKIN:WASH THORO W/SOAP &
H2O. LAUNDER CONTAM CLTHG. INHAL:IF RESP DISCOMFORT/IRRIT OCCURS,
MOVE PER S TO FRESH AIR. SEE MD IF DISCOMFORT/IRRIT CONTINUES.
INGEST:GIVE H2O/MILK & CALL FOR MED ADVICE. DO NOT MAKE PERS VOMIT
UNLESS DIRECTED TO DO SO BY MD. IF MED ADVICE CANNOT BE OBTAINED,
(SUPDAT)

Flash Point Method:COC
Flash Point:293F,145C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:DO NOT USE PRESSURE TO EMPTY DRUM OR
EXPLOSION MAY RESULT.

Spill Release Procedures:STOP SOURCE OF LEAK/RELEASE. CLEAN UP RELEASE
ASAP, OBSERVING PRECS. CONTAIN LIQ TO PVNT FURTHER CONTAM OF SOIL,
SURF WATER/GROUNDWATER. CLEAN UP SM SPILLS USING APPROP TECHNIQUES
SUCH AS SORBENT MATL /PUMPING. WHERE FEASIBLE & APPROP,
REMOVE(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:READ AND OBSERVE ALL PRECAUTIONS ON
PRODUCT LABEL. CONTAINS PETROLEUM DISTILLATE. DO NOT WELD,
HEAT/DRILL CONTAINER.
Other Precautions:REPLACE CAP OR BUNG. EMPTIED CONTAINER STILL CONTAINS
HAZARDOUS OR EXPLOSIVE VAPOR OR LIQUID. DO NOT USE PRESSURE TO
EMPTY DRUM OR EXPLOSION MAY RESULT. AVOID PROLONGED OR REPEATED
SKIN CONTACT.

Respiratory Protection:NO SPECIAL RESPIRATORY PROTECTION IS NORMALLY
REQUIRED. HOWEVER, IF OPERATING CONDITIONS CREATE AIRBORNE
CONCENTRATIONS WHICH EXCEED EXPOSURE STANDARD, USE AN NIOSH/MSHA
APPROVED RESPIRATOR.
Ventilation:USE ADEQUATE VENTILATION TO KEEP AIRBORNE CONCENTRATIONS OF
MATERIAL BELOW FEDERAL OSHA EXPOSURE STANDARD.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:IMPERVIOUS CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
EFTS OF OVEREXP:OF EXPOS):NASAL DISCHARGE, SORE THROAT, COUGHING,
BRONCH, PULM EDEMA & DFCLTY IN BRTHG. FIRST AID PROC:TAKE PERS &
PROD CONTR TO NEAREST MED EMER TREATMENT CTR/HOSP. SPILL
PROC:CONTAM SOIL FOLLOW PRESCRIBED PROCS FOR REPORTING &
RESPONDING TO LARGE RELEASES.

HCC:V6
Spec Gravity:0.91 @ 15.6C
Solubility in Water:INSOLUBLE
Appearance and Odor:PALE YELLOW LIQUID.

Stability Indicator/Materials to Avoid:YES
MAY REACT WITH STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NORMAL COMBUSTION FORMS CO2 & H2O
VAPOR; INCOMPLETE COMBUSTION CAN PRODUCE CO.

Waste Disposal Methods:MATL IS NOT EXPECTED TO PRESENT ANY ENVIRON
PROBLEMS OTHER THAN THOSE ASSOC W/OIL SPILLS. PLACE CONTAM MATL IN
DISPOSABLE CONTRS & DISP OF IN MANNER CONSISTENT W/APPLIC
LOC/STATE/FED REG. CONTACT LOC ENVIRON/HLTH AUTHORITIES FOR APPRVD
DISP FOR MATL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.